Product ID:4315 HEAT RESISTANT ALUMINUM
MSDS Date:02/08/1990
FSC:6850
NIIN:00F003773
MSDS Number: BTTXY

RUST-OLEUM CORP

11 HAWTHORN PKWY
VERNON HILLS, IL 60061-1583
US

Emergency Phone: 708-367-7700

Info Phone: 708-367-7700

Cage: 08882

RUST-OLEUM CORP

VERNON HILLS, IL 60061-1583 US

Telephone: 847-367-7700

Cage: 08882

XYLENE, DIMETHYLBENZENE, XYLOL

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 35%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 15%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: BRAIN/NERVOUS SYSTEM
EFFECTS, NOSE & THROAT IRRITATION. SKIN/EYES: IRRITATION.
INGESTION: GI IRRITATION. CHRONIC: DERMATITIS W/REPEATED
OVEREXPOSURE. REPEATED/PROLONGED OVEREXPOSURE TO SOL VENTS
ASSOCIATED W/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. OVEREXPOSURE
TO XYLOL HAS SHOWN LIVER/CARDIAC ABNORMALITIES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, HEADACHE, NAUSEA, STAGGERING GAIT,
CONFUSION, UNCONSCIOUSNESS, COMA, IRRITATION, VOMITING, DIARRHEA

First Aid:INHALATION: REMOVE FROM EXPOSURE & RESTORE BREATHING. EYES:
FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINS.
SKIN: WASH AREA W/SOAP & WATER. INGESTION: DON'T INDUCE VOMITING.
KEEP WARM & QUIET. ASPIRATION HAZARD. OBTAIN MEDICAL ATTENTION IN
ALL CASES.

Flash Point Method:SCC
Flash Point:80F
Extinguishing Media:NFPA CLASS B EXTINGUISHERS: CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERRED.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
& REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS.

Handling and Storage Precautions:DON'T STORE >120F. STORE LARGE
QUANTITIES IN APPROPRIATE BUILDING. CONTAINERS SHOULD BE GROUNDED
WHEN POURING. EMPTY CONTAINERS MAY BE HAZARDOUS.
Other Precautions:KEEP CONTAINERS TIGHTLY CLOSED. DON'T APPLY TO HOT
SURFACES.

Respiratory Protection:USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR
TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY & ORGANIC VAPORS
DURING SPRAY APPLICATION. IN CONFINED AREAS USE NIOSH APPROVED
SUPPLIED-AIR RESPIRATOR S/HOODS.
Ventilation:PROVIDE GENERAL DILUTION/LOCAL EXHAUST VENTILATION IN
VOLUME & PATTERN TO KEEP TLV BELOW ACCEPTABLE LIMIT.
Protective Gloves:REQUIRED
Eye Protection:SAFETY EYEWEAR
Work Hygienic Practices:REMOVE & LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SPECIAL FIRE FIGHTING PROCEDURES: WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD-UP & POSSIBLE
AUTOIGNITION/EXPLOSION.

Boiling Pt:B.P. Text:282-389F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:70

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAME,
ELECTRICAL EQUIPMENT
Hazardous Decomposition Products:CO, CO2

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.DON'T INCINERATE CLOSED CONTAINERS. FLAMMABLE PAINT
LIQUID UN 1263.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.